View CartMy Account / Order StatusHelp

Join our mailing list!



(Your shopping cart is empty)
You are here: Home > Battery Charger Parts > Schumacher Battery Charger Repair Parts > INC-3625A Schumacher 36 Volt 25 Amp Battery Charger Parts List
INC-3625A Schumacher 36 Volt 25 Amp Battery Charger Parts List 94080057-R8

Schumacher INC-3625A Troubleshooting Guide
PROBLEM POSSIBLE CAUSE SOLUTION
The charger is making an audible clicking sound. Circuit breaker is cycling. The settings may be wrong. Check the charger settings.
Battery is defective. Have the battery checked.
Shorted battery cables or connector. Circuit breaker cycles when current draw is too high. Check for shorted cables or connector and replace if necessary.
Severely discharged battery, but otherwise it is a good battery. The battery may not want to accept a charge due to a run-down state. Allow charging to continue until battery has a chance to recover sufficiently to take a charge. If more than 20 minutes, stop charging and have the battery checked.
Reverse connections at battery. Shut the charger off and correct the lead connections.
Charger makes a loud buzz or hum. Transformer laminations vibrate (buzz). No problem, this is a normal condition.
Shorted Diode Assembly or Output Rectifier Assembly (hum). Have charger checked by a qualified technician.
CHARGING (yellow) LED is blinking. Indicates the charger is in abort mode. See “Abort Mode” in the OPERATING INSTRUCTIONS Section.
The battery is connected and the charger is on, but is not charging. Connector is not making a good connection. Check for poor connection at battery. Make sure connecting points are clean. Rock connector back and forth for a better connection.
The measured current is much lower than what was selected. The charger reached the maximum voltage and is reducing the current. No problem, this is a normal condition.
Schumacher User Manual Link




When a charging problem arises, make certain that the battery is capable of accepting a normal charge. Double check all connections, AC outlet for a full 120-volts, charger clips for correct polarity and the quality of the connections from the cables to the clips and from the clips to the battery system. The clips must be clean.

When a battery is very cold, partially charged or sulfated, it will not draw the full rated amperes from the charger. It is both dangerous and damaging to a battery to force higher amperage into it than it can effectively use in recharging.

Sort By:
Page of 1
Bench Charge For Industrial Battery Chargers
Industrial Battery Charger Repair
Rate $35.00

Bench Charge For Industrial Battery Chargers includes teardown of charger and estimate of repairs for Series and Parallel and Large units.
0090026218 Schumacher 115 Volt Power Cord 86"
0090026218 Schumacher 115 Volt Power Cord 86"
Price $16.48

0090026218 Schumacher 115 Volt Power Cord 86" 14/3 SJTOW terminals .25 x .25 S/R
0400700026 SPDT Relay 12 Volt 30 Amp Panel Mount
0400700026 SPDT Relay 12 Volt 30 Amp Panel Mount
Price $12.52

Single Pole Double Throw Relay 12 Volt coil 30 Amp contacts Panel Mount with quick connect terminals.
0499000121 SPST Switch Lighted 16 Amp
0499000121 SPST Switch Lighted 16 Amp
Price $14.28

0499000121 SPST Switch Lighted 16 Amp
2299001902 Schumacher Cable Plug Set 8ga 6 foot
2299001902 Schumacher Cable Plug Set 8ga
Price $44.64

2299001902 Schumacher Cable Plug Set 8ga 6 foot
2299002090 Schumacher Heat Sink Power Board INC/LVS-36
2299002090 Schumacher Heat Sink Power Board INC/LVS-36
Price $41.85

2299002090 Schumacher Heat Sink Power Board INC/LVS-36
3599000200 Schumacher Battery Charger Handle
3599000200 Schumacher Battery Charger Handle
Price $5.25

3599000200 Schumacher Battery Charger Handle. 4-15/16" Hole Centers.
3999000127 Schumacher Toe Blade Fuse 40 Amp 58 Volts
3999000127 Schumacher Fuse 40 Amp 58 Volts DC
Price $8.92

3999000127 Schumacher Toe Blade Fuse 40 Amp 58 Volts
4999000078 Schumacher Cooling Fan 12 VDC
4999000078 Schumacher Cooling Fan 12 VDC
Price $12.52

Cooling Fan 12 VDC 92 x 92 x 25 mm 8" lead set.
INC-3625A Schumacher 15-25 Amp 36 Volt Automatic Bench Battery Charger
INC-3625A Schumacher 15-25 Amp 36 Volt Automatic Bench Battery Charger
Price $249.95

The Schumacher INC-3625A is a 36 volt fully automatic, microprocessor controlled charger with a 15 to 25 amp cycling output current. Maintain mode – monitors the battery voltage to keep it fully charged. Reverse polarity and short circuit protection will ensure this until will not apply current to the output connect until it is properly connected. Patent pending 'thermal runaway' protection stops charging if the charger detects that there is a problem with the battery. Automatic temperature compensation automatically adjusts the output voltage based on the ambient air temperature. Charges 36 volt lead-acid batteries, perfect for golf carts, tow tractors and people movers. Temperature controlled cooling fan for efficient operation and peak performance. Power saving mode – uses very little power when in standby mode or maintain mode.
   
 
*Variations of models due to production changes and parts availability are not our responsibility
*No refunds on electrical components
*Service should be performed only by a qualified technician
*Please read all supporting documentation and safety instructions
Century Tool & Equipment
4013 S. Old Hwy 94
St. Peters MO 63304
 About Us
 Let Us Repair It
 Privacy Policy
 Send Us Feedback